Douglas C-124 Globemaster II

Despite having been the world's largest landplane transport when it flew in 1945, the Douglas C-74 Globemaster was actually too small-in volume-to accommodate the outsized loads dictated by the American military's postwar logistical needs. In response to this problem, the fifth C-74 was held back at the factory to undergo far- reaching modifications under the new designation YC-124. Using the wings, engine nacelles, and tail group of the C-74, Douglas evolved an entirely new fuselage by adding five feet ten inches to overall length, raising the height of the main cargo bay five feet, and lowering the depth of forward fuselage to permit loading of trucks, artillery pieces, aircraft sub- assemblies, or bulky equipment through a set of full- width clamshell doors in a new nose section that incorporated a built- in, hydraulically lowered ramp. The aft, belly loading hatch of the C-74 was retained, and to assist fore and aft movement of large loads, two overhead hoists, with 16,000 lbs. lifting capacity each, were installed in the main cargo bay. When rigged in a double deck configuration, the new fuselage design could also house 200 fully equipped troops or 127 evacuees in medical litters.

Dubbed "Globemaster II," the YC-124 completed its maiden flight on November 27, 1949, and deliveries of the first of 204 C-124A production models to the USAF commenced in May 1950. The prototype became the YC-124A when re- powered with 3,800-hp R-4360-35A engines, then reemerged in 1954 as the YC-124B after being modified to serve as a flying testbed for 5,500-shp Pratt & Whitney YT34 turboprop engines. A KC-124B tanker variant was considered as a potential KC-97 replacement but never materialized. The Long Beach plant shifted to production of 243 improved C-124Cs delivered between 1952 and 1955, which differed in having 3,800-hp R-4360-63A engines, an APS-42 weather radar in a nose- mounted thimble radome, and wingtip- mounted combustion heaters that provided thermal de-icing and cabin heating, and over a period of years, the existing C-124A fleet received retrofits that brought them up to the C standard. A pressurized variant was studied as the C-124X but never built, and during the mid-1950s, a much redesigned turboprop- powered, swept- wing derivative, designated XC-132, got as far as the mockup stage but was ultimately canceled in favor of the C-133.

C-124As began entering service during 1950 in time to play an important role in the Korean War (1950-1953). For the first time, MATS possessed a long- range aircraft capable of loading bulky items like tanks, guns, trucks, and construction equipment without major disassembly; and in Strategic Support Squadrons, new Globemasters gave SAC the ability to deliver large aircraft components to any of its widespread bases. As the USAF's C-124A and C fleet grew to planned strength in the mid-1950s, it formed the bulk- carrying nucleus of every major U.S. military airlift operation conducted from that time up until the late 1960s. Some of the C-124's more notable achievements included moving an entire squadron of Lockheed F-104s from the U.S. to Taiwan during the Formosa Straits Crisis in 1958; during Operation Deep Freeze (1957-1962), regular airdrops from C-124s formed the supply line from McMurdo Base to outlying stations in the Antarctic; and as part of Operation Big Lift in 1963, MATS C-124s moved the 2nd Armored Division and a TAC Strike Force from U.S. bases to Germany in two and a half days.

At their peak in 1963, 377 C-124s were operating with 20 different transport squadrons. As American involvement in Southeast Asia escalated in the mid-1960s, C-124s began flying transport sorties directly into South Vietnam, and from early 1966, continued with Military Airlift Command (MAC) when that organization replaced MATS. Although the USAF started the process of phasing- out C-124s from frontline service and transferring them to reserve and ANG units in mid-1960s, the type's bulk cargo capacity was not matched until Lockheed C-5s became operational with MAC during 1969-1970. From 1964 to 1972, to augment MATS/MAC operations, USAF reserve units flew C-124s on overseas sorties from eleven different bases within the continental U.S., and starting in 1966, they also served in eight ANG squadrons until the last examples were retired in mid-1974, finally ending the type's military service. The last recorded flight of a C-124 occurred on October 9, 1986 when C-124C AF Ser. No. 52-0994 was ferried from Selfridge ANG Base, Michigan to McChord AFB, Washington.

E.R.Johnson "American military transport aircraft since 1925", 2013

There was little doubt of the load-carrying capability of the C-74 and when, in late 1947, the newly-formed US Air Force decided it needed a heavy strategic cargo transport, discussions between the.USAF and Douglas resulted in development of the C-124 Globemaster II, based on the C-74.

In fact, the prototype YC-124 was basically the fifth C-74 provided with a new, deeper fuselage and strengthened landing gear. Powered by 2610kW R-4360-49 radial engines, it was flown for the first time on 27 November 1949. The type entered production as the C-124A, of which 204 were built, the first of them entering service with the USAF in May 1950. The next, and final, production version was the C-124C, with more-powerful R-4360 engines, weather radar in a distinctive nose radome and, equally useful recognition points, wingtip fairings housing combustion heaters to de-ice the wing and tailplane leading edges and to heat the cabin. C-124C production totalled 243, the last machine being delivered during May 1955.

The fuselage of the Globemaster II had clamshell nose loading doors with an associated built-in loading ramp, an electric hoist amidships which was a carry-over from the C-74, and two overhead cranes (each with a capacity of 7257kg which could traverse the entire length of the 23.47m-long cargo hold. The flight deck, accommodating a crew of five, was mounted high in the nose, over the clamshell doors. When used in a transport role (with two decks installed), the Globemaster II could carry a maximum of 200 fully-equipped troops, or 123 stretcher cases plus 45 ambulatory patients and 15 medical attendants.

Serving with the USAF's Air Materiel Command, Far Eastern Air Force, Military Air Transport Service, Strategic Air Command and Tactical Air Command, and used in conjunction with Douglas C-133s, the Globemaster Us remained in service until replaced by the Lockheed C-5A Galaxy during 1970.

When the Globemaster Is ended their useful, service life; some were acquired by civil cargo operators.

D.Donald "The Encyclopedia of World Aircraft", 1997

Marvin Medlin, e-mail, 27.01.2022 Bud Winnett

Went to anartica 1959 Deep Freeze 60 on c124 stayed into 1961,drove a Cat D 8LGP TO Pole from Byrd Station that had been at Little America with Admiral Byrd .Too big to fly 90k lbs unless hauled in pieces .1957 D 4 Cats were dropped at the pole from an A F Globemaster. First one slipped side ways on pallet causing 5 chutes not to fully open from 150 ft. Second D4 was a successful drop & 30 min after was in use.All material ,fuel man power were dropped that year.C130,s ended

reply

James R. (Jim) Fox, e-mail, 27.05.2022 Richard Casper

Richard, I was taking a stroll down memory lane when I came across your post about when you were at Dover AFB.
I was at Dover at the same time as you and I was in the 1607 FLMS as I assume you were.
I worked the flight line as an assistant supervisor and was a staff sergeant at the time.
I also taught engines and APG in the squadron training section.
I had a deep affection for the C-124 and really enjoyed my association with it.
Don’t know if you are aware that C-124-C
52-1066 is in the Air Force museum at Wright Patterson AFB. It has a different tail number on it now, but there is a plaque that tells that number 52-1066 is correct, so you, as I, no doubt worked on it.
Hope all has gone well with you since your Air Force days.

reply

James R. (Jim) Fox, e-mail, 27.05.2022 Richard Casper

Richard, I was taking a stroll down memory lane when I came across your post about when you were at Dover AFB.
I was at Dover at the same time as you and I was in the 1607 FLMS as I assume you were.
I worked the flight line as an assistant supervisor and was a staff sergeant at the time.
I also taught engines and APG in the squadron training section.
I had a deep affection for the C-124 and really enjoyed my association with it.
Don’t know if you are aware that C-124-C
52-1066 is in the Air Force museum at Wright Patterson AFB. It has a different tail number on it now, but there is a plaque that tells that number 52-1066 is correct, so you, as I, no doubt worked on it.
Hope all has gone well with you since your Air Force days.

reply